Jeep 6 speed manual transmission problems

 · Jeep Wrangler 2dr 4wd w/6speed manual transmission. This is a known problem according to a recent dealership service visit that they are "fully aware of". The gear shift frequently pops out of 1st gear while starting from a standstill. Vehicle has .  · I'm running a 6 speed in my Jeep count "1 One thousand, 2" between shifts. You've got to allow time for syncronization so all you need to do is slow your shifts. What I do is push in the clutch and apply pressure to the shifter to "drop" out of gear then count and time your shift. I think the front bearing on this transmission is a little www.doorway.ru Interaction Count: Jeep Wrangler Manual Transmission Problems. If you have a Manual Jeep Wrangler and the vehicle feels underpowered and goes into the limp mode it could be any of the following: Fuel Pump; Fuel Relay; A clog in the fuel line; Faulty PCM control moduleEstimated Reading Time: 9 mins.

The manual transmission in your Jeep is a NSG, which was actually introduced in in the TJ's. So, with your bellhousing, couldn't you source a 6 speed from a TJ also? Not to mention that you should be able to source some parts for the transmission using the name of he trans, rather than the application. 6 speed manual transmission problem. Jump to Latest Follow 1 - 9 of 9 Posts. Masman4 · Registered. Joined Nov 3, · Posts. Discussion Starter · #1 · . Only show this user Wtf is wrong with my jeep. Save Share. Reply. DeepSouthJeeper. I have a Jeep Wrangler, 25k miles, , 6 speed manual. The transmission is no where near as smooth and responsive as my 5 speed. It chinks, clunks and chips into gear sometimes--usually shi read more.

This six-speed manual transmission has an integral bellhousing in the front case and as is common in European design is loaded longitudinally. Fifth gear is ratio (direct drive) and sixth is overdriven, so be aware of this when you are diagnosing a problem. there is a TSB on the 05 and 06 6-speed's, something do with a little piece in the clutch. it breaks and you cant put the pedal down. make sure that has been fixed properly. other than that its a good trans. Useful Write-Ups: To view links or images in signatures your post count must be 10 or greater. Jeep Wrangler 2dr 4wd w/6speed manual transmission. This is a known problem according to a recent dealership service visit that they are "fully aware of". The gear shift frequently pops out of 1st gear while starting from a standstill. Vehicle has 28, miles on it, issue had begun at about k.